Chunying Min*,
Qiaqia Zhang,
Chen Shen,
Dengdeng Liu,
Xiaojuan Shen,
Haojie Song,
Songjun Li,
Dong Xu,
Xingyu Lin and
Kan Zhang*
Institute of Polymer Materials, School of Material Science and Engineering, Jiangsu University, Zhenjiang, Jiangsu 212013, P. R. China. E-mail: mj790206@ujs.edu.cn; zhangkan@ujs.edu.cn
First published on 26th June 2017
The development of water-based lubricants with well dispersed ultrafine particles is in high demand. In this article, graphene oxide (GO) nanosheets/carboxyl-functionalized multi-walled carbon nanotubes (MWCNTs–COOH) hybrids have been synthesized via vacuum filtration of a solution hybrid dispersion, as additives for water-based lubricants. The tribological performance of GO/MWCNTs–COOH hybrids in water was systematically investigated. The lubrication properties of water-based lubricant can be significantly improved by adding GO/MWCNTs–COOH hybrids in comparison with adding only GO nanosheets or MWCNTs–COOH as lubricant additives. Notably, the water with as little as 0.7 wt% of GO/MWCNTs–COOH hybrids exhibits the best lubrication performance in terms of friction and wear reduction. This unique tribological performance of GO/MWCNTs–COOH hybrids in water suggests the existence of a synergistic effect of GO and MWCNTs–COOH on reducing friction and wear.
Recently, water-based lubricants have become a series of new and promising high performance lubricants with applications in hydraulic fluid, cutting fluid, and the oil extraction industry owing to its high thermal conductivity, low working temperature, and its endless resources. However, low corrosion resistance and high wear rate limit its wider applications. At present, various forms of carbon-based nanomaterials (i.e., nano-tube, nano-onions, nano-diamond, etc.) are used to reduce friction and wear and this has gained high attention.5–8 Compared to traditional metal (Cu, Ag, Al) and their corresponding oxide nanoparticles (CuO, Al2O3, Ag2O), carbon-based nanomaterials exhibit unique properties including high corrosion resistance, strong environmental adaptability, outstanding tribological properties and good dispersibility with water-based lubricants, leading their enhanced lubrication properties under different conditions.
Carbon nanotubes (CNTs), a one-dimensional nano carbon material, offers extraordinary physical and chemical properties, such as corrosion resistance, high temperature resistance, heat resistance, good thermal and electrical conductivity, lubricity, etc.9–11 CNT can be a potential candidate as water-based lubricant additive after modification with hydrophilic functionalities. Meng et al.12 found that CNTs could improve the wear resistance as well as reduce the friction coefficient of polyamide 6 considerably under both dry sliding and water-lubricated conditions. However, Shen et al.13 reported that CNTs could not improve the lubricating performance of nanofluids because of high friction between molecules and high molecular strength. In our previous study, we discovered that the incorporation of carboxyl-functionalized multi-walled carbon nanotubes (MWCNTs–COOH) can significantly enhance the mechanical properties and thermal stability of polyimides.14
Hybrid nanocomposites have recently attracted a large number of researchers' interests with various combinations of mixtures being studied, for instance, MWCNT with carbon black,15 few layer graphene with single walled CNT and nano diamonds16 and MWCNT with graphene nanoplatelets (GnP).17 S. Chatterjee et al.18 have found a synergistic effect of CNT and GnP on epoxy composites. It has been extensively reported that modified nano-carbon materials can improve their compatibility with water-based lubricants. In addition, graphene,19–22 a two-dimensional carbon material, has raised widespread concerns about its commendable properties, such as high thermal conductivity, high Young's modulus, large specific surface area and anti-wear properties. Graphene oxide (GO), as a derivative of graphene, has a large number of oxygen-containing functional groups on its plane, making it possess well water solubility and dispersibility. Thus, as additives in water-based lubricants, GO nanosheets are much more feasible compared with graphene. Song et al.23 investigated GO nanosheets and confirmed that they can improve the anti-wear and anti-friction properties in water. Besides, Sarno et al.24 studied the GO sheets as additives in oil-based lubricants. Oskari Elomaa et al.25 have found that the water-based lubricants with dispersed GO exhibit lower friction in diamond-like carbon in comparision with stainless steel tribological contacts. Moreover, Cote26 has illustrated that graphene oxide as surfactant sheets can improve the water solubility of carbon nanotubes, and non-metallic carbon materials as additives only containing C, H and O instead of heavy metal elements and toxic particles coincide with the purpose of environmental protection. However, the flat shape of Go leads it readily sticking to each other, thereby decreasing the tribological performance of its corresponding lubricants. Interestingly, the crumpled graphene could exhibit advantages both in self-dispersion and aggregation resistance even without oxidation in oil, making it an attractive materials for tribological applications.27
From all these findings, we were encouraged to find a facile approach to prepare high-performance additives for water-based lubricants via CNT and graphene nanoparticles. In this study, GO/MWCNTs–COOH hybrids have been synthesized by vacuum filtration of solution hybrid dispersion and applied as water-based lubricant additives. We demonstrate that GO/MWCNTs–COOH hybrids as additives in water is indeed a superior friction modifier compared with both GO and MWCNTs–COOH particles. Remarkably, the water with as less as 0.7 wt% GO/MWCNTs–COOH hybrids exhibits the best lubrication performance in terms of friction and wear reduction. Furthermore, the tribological mechanism of GO/MWCNTs–COOH hybrids has also been proposed.
Tribological properties of the above suspension samples with different weight concentrations of additives were tested using a universal micro-tribotester (UMT-2, Center for Tribology Inc., USA). The measurement for friction was conducted with a ball on the disc friction with a rotation speed of 0.0523 m s−1. The load force was keeping under a constant load of 10 N and the test duration was as long as 30 min. The stainless steel ball with a diameter of 4 mm and a hardness of 61 HRC was made of GCr15 bearing steel (AISI 52100). The rotation radius is 3 mm. The steel balls and steel disc were cleaned by acetone and dried before tests. All the friction and wear tests of the samples were carried out in air at ambient temperature and a relative humidity of 50–60%. The worn surfaces of steel ball were measured by Zeiss Observer Z1m metalloscope. Three-dimensional contours of wear track were measured by Keyence VHX-1000.
The wear volume V (mm3) of worn surface of steel ball was calculated by following formula:
(1) |
The specific wear rate K [mm3 (Nm)−1] of counterpart steel ball surface was calculated according to the formula:29
(2) |
Fig. 1 SEM images of GO nanosheets (a), MWCNTs–COOH (c), cross-sections of GO/MWCNTs–COOH–3-1 hybrid (d), AFM images of GO nanosheets (b). |
Fig. 2 TEM images of hybrids derived from different weight ratio (a) GO/MWCNTs–COOH hybrids-9-1, (b) GO/MWCNTs–COOH hybrids-3-1, (c) GO/MWCNTs–COOH hybrids-1-1, (d) GO/MWCNTs–COOH hybrids-1-3. |
The configuration of GO/MWCNTs–COOH hybrids with different weight ratio of GO and MWCNTs–COOH was frontally observed by TEM (Fig. 2) in which the MWCNTs are grown on the surface of GO nanosheets. As the ratio of GO and MWCNTs–COOH reaches 9:1, such low weight concentration of MWCNTs–COOH is not efficient to form uniform network as shown in Fig. 2(a). Besides, slight aggregation can be seen in Fig. 2(c), and MWCNTs–COOH aggregates seriously in Fig. 2(d). However, when the ratio of GO nanosheets and MWCNTs–COOH is 3:1, the network of GO/MWCNTs–COOH hybrid seems more uniform as presented in Fig. 2(b).
Fig. 3 shows the Raman spectra of GO/MWCNTs–COOH hybrids derived from different weight ratios of GO and MWCNTs. The D-band at 1350 cm−1 represents the disordered sp3 structure and the G-band at 1590 cm−1 corresponds to the sp2 hybridized graphitic structure.30 It is noted that the intensity ratio of D-band and G-band (ID/IG) can describe the defect of carbon structure.31,32 The ratio of ID/IG of GO/MWCNTs–COOH–3-1 was calculated as 0.94. In addition, the ratio of ID/IG increases obviously as increasing the concentration of MWCNTs–COOH.
Powders of GO nanosheets, MWCNTs–COOH and GO/MWCNTs–COOH–3-1 hybrids were sonicated in water until they were fully dispersed in water with no residual solids remaining. All three additives can initially disperse in the water right after sonication (Fig. 4(a–c)). The GO nanosheets solution exhibits brown color due to the loss of electronic conjugation by oxidation, carboxyl, hydroxyl and epoxy groups, which are grafted onto the edge and surfaces of GO nanosheets, making GO nanosheets partially hydrophilic that insure the stable dispersion in aqueous medium.23 CNTs after acidification also gained relatively stable water-soluble in a short-term. However, agglomeration was apparent after few days (Fig. 4(c)). After two weeks, GO and GO/MWCNTs–COOH hybrids were still dispersed in the water, but the CNTs–COOH additives were fully sedimented as shown in Fig. 4(a–c). Fig. 4 indicates that GO nanosheets is capable of improving the dispersibility of MWCNTs–COOH in water, which is possible due to the π–π interactions between the CNTs–COOH and π patches on GO basal plane.33 The superior self-disperse property in water of GO/MWCNTs–COOH hybrids suggests it as potential candidate for lubrication application.
The friction and wear behaviors of GO/MWCNTs–COOH hybrids were investigated as lubricant additives in pure water. The as-prepared GO/MWCNTs–COOH hybrids derived from different weight ratios (1:1, 1:3, 1:9, 3:1, 9:1) of GO and MWCNTs–COOH with a content of 0.3 wt% in water were chosen to evaluate the tribological properties. The friction coefficients and wear rates of water lubricants with additives of GO/MWCNTs–COOH hybrids are as shown in Fig. 5. It is obvious that the different ratio of GO nanosheets and MWCNTs–COOH significantly influences the tribological properties of water lubricants. Especially, as the weight ratio of GO and MWCNTs–COOH comes to 3:1, the water lubricant with GO/MWCNTs–COOH exhibits the best tribological performance with the lowest friction coefficient and wear rate. It indicates that the existence of the synergistic effect between GO nanosheets and MWCNTs–COOH leads superior tribological properties of water lubricants. In particular, the ratio of GO nanosheets and MWCNTs–COOH is an essential factor affecting the reinforcing capabilities of the hybrids. Previous report18 suggested that MWCNTs are readily assembled on the GO nanosheet surfaces, creating an inter-connected strong nanofiller network. Therefore, the homogeneous dispersion of particles causes improved lubrication properties.
Fig. 5 Friction coefficients (a) and wear rates (b) of varying ratios of GO/MWCNTs–COOH hybrids dispersed in pure water. |
To further investigate the lubrication performance of water-based lubricants with GO/MWCNTs–COOH additives, we have systematically investigated the effect of different contents of GO/MWCNTs–COOH–3-1 hybrids on tribological properties. In addition, the triblogical properties of water-based lubricants with different contents of GO and CNTs–COOH were also studied for comparison. As the three additives are dispersed in water, friction coefficients of water-based lubricants show a decrease trend going with the increase of contents in Fig. 6(a). When content of additives is less or equal to 0.5 wt%, friction coefficient of water with GO nanosheets is lower than the other two lubricants. However, as the content of additives reaches more than 0.5 wt%, the friction coefficient of lubricant with GO/MWCNTs–COOH–3-1 hybrids exhibits much lower than that of GO and MWCNTs–COOH, and the friction coefficient of water with 0.7 wt% GO/MWCNTs–COOH–3-1 hybrids reaches minimum. Observed from Fig. 6(b), all of the three carbon materials can reduce wear rates visibly, in which abrasive resistance of GO/MWCNTs–COOH hybrids is superior to GO and MWCNTs–COOH as additives. Furthermore, the wear rates of GO/MWCNTs–COOH–3-1 hybrids as water-based lubricant additives are very stable with the increase of weight concentration. Thus, 0.7 wt% of GO/MWCNTs–COOH–3-1 hybrids as additive exhibits the most excellent tribological performance.
The worn surface of steel ball and the three-dimensional profile of wear track of counterparts under water-based lubrication were displayed in Fig. 7(a–d). Therein, wear spot diameter of worn surface of steel ball under pure water in Fig. 7(a) is larger, wear track is deeper, and visible wear degree is distinct. The worn surface of steel ball under 0.7 wt% GO nanosheets, 0.7 wt% MWCNTs–COOH and 0.7 wt% GO/MWCNTs–COOH–3-1 hybrids as additives added in pure water were shown in Fig. 7(b–d). From the comparison of the worn surfaces, it is obvious that the wear diameter can be significantly reduced with the addition of the above three kinds of carbon additives. Besides, we can further observe that the wear spot diameter reaches minimum in case of the addition of 0.7 wt% GO/MWCNTs–COOH–3-1 hybrids. The results indicate that GO/MWCNTs–COOH hybrids play a remarkable role in improving lubrication performance, which is consistent with the above results in terms of frication and wear reduction.
Fig. 8 presents SEM images of the steel disc lubricated with pure water (a) and water with 0.7 wt% GO nanosheets (b), 0.7 wt% MWCNTs–COOH (c) and 0.7 wt% GO/MWCNTs–COOH–3-1 hybrids (d). The worn surface lubricated with pure water is obviously rough with many furrows and some debris which may be caused by the contact fatigue and adhesive fatigue. In comparison, the worn surfaces lubricated by water with carbon additives show less and lighter furrows, clearly indicating that all of the three additives added into water can protect the friction surface from direct contact and reduce friction intuitively. In particular, GO/MWCNTs–COOH hybrids as water additive show a smoother and flatter wear track corresponding to the lowest friction coefficient and the lowest wear rate. It can be concluded that the water with GO/MWCNTs–COOH hybrids can obtain prominent anti-friction and wear resistance ability.
In this study, the GO/MWCNTs–COOH hybrids as water-based additive have superior wear-resisting ability as well as a very low friction coefficient has been reached at 0.7 wt%. The friction reducing mechanism between friction interfaces with GO/MWCNTs–COOH hybrids is graphically expressed in Fig. 9. We have speculated the possible mechanism of friction reduction in the case of GO/MWCNTs–COOH hybrids dispersion in water. The synergistic effects26,34 of GO/MWCNTs–COOH hybrids make compounds can be well dispersed in water-based fluids, for that GO nanosheets and MWCNTs–COOH were combined by π–π non covalent bonding extending interlayer and tube space. During the sliding, friction shear force between the steel ball and steel disc is stronger than the force of π–π non covalent bonding, which easily leads GO nanosheets transfer to worn surfaces. As a result, Go could not only bear the load on the steel ball but also prevent the steel ball and steel disc from direct contact. Furthermore, MWCNTs–COOH in the hybrids can play a role as micro-bearings to change sliding friction into rolling friction between the worn surfaces. Therefore, an excellent lubrication performance can be achieved under the water-based lubricant with additives of GO/MWCNTs–COOH hybrids.
This journal is © The Royal Society of Chemistry 2017 |